Product ID:F-117 & F117 BLUE ACID COMPONENT F-39P01
MSDS Date:09/28/1993
FSC:8010
NIIN:00N067078
MSDS Number: CBWLT

SEAGRAVE COATINGS CORP OF VA

4030 SEAGRAVE AVE
PORTSMOUTH, VA 23701
US

Emergency Phone: 804-488-4411

Info Phone: 804-488-4411

Cage: 60163

SHERWIN-WILLIAMS, SEAGUARD

PORTSMOUTH, VA 23704 US

Telephone: 757-397-2223

Cage: 60163

PHOSPHORIC ACID; (PHOSPHORIC ACID 75%) (SARA 313) (CERCLA)

CAS: 7664-38-2

RTECS: TB6300000

Fraction By Weight: 20%

OSHA PEL 1 MG/M3

ACGIH TLV: 1 MG/M3/3 STEL

EPA Report Quantity: 5000 LBS

DOT Report Quantity: 5000 LBS

96

CAS: 67-63-0

RTECS: NT8050000

Fraction By Weight: 70%

OSHA PEL 400 PPM

ACGIH TLV: 400 PPM/500STEL

882

RTECS: 9999999VO

OSHA PEL N/K

ACGIH TLV: N/K

LD50 LC50 Mixture:NONE SPECIFIED BY MANUFACTURER.
Routes of Entry: Inhalation:YES Skin:YES Ingestion:YES
Reports of Carcinogenicity:NTP:NO IARC:NO OSHA:NO
Health Hazards Acute and Chronic:BREATHING OF HIGH VAPOR CONCENTRATIONS
MAY PRODUCE NARCOSIS. LIQUID MAY CAUSE MINOR SKIN IRRITATION AND
DEFINITE EYE IRRITATION. CORROSIVE; HARMFUL IF INHALED. CAUSES NOSE
AND THROAT IRRITATION. CAUSE S EYE AND SKIN IRRITATION. REPEATED
ANDPROLONGED OVEREXPOSURE TO SOLVENTS COULD CAUSE PERMANENT BRAIN
(EFTS OF OVEREXP)
Explanation of Carcinogenicity:NOT RELEVANT
Effects of Overexposure:HLTH HAZS:AND NERVOUS SYSTEM DAMAGE.
INTENTIONAL MISUSE BY DELIBERATELY COCENTRATING AND INHALING
CONTENTS MAY BE HARMFUL OR FATAL.
Medical Cond Aggravated by Exposure:NONE SPECIFIED BY MANUFACTURER.

First Aid:INHALATION:REMOVE TO FRESH AIR. RESTORE BREATHING. CONSULT A
PHYSICIAN. SKIN:FLUSH WITH PLENTY OF WATER FOR AT LEAST 15 MINUTES
WHILE REMOVING CONTAMINATED CLOTHING/SHOES. GET IMMEDIATE MEDICAL
ATTENT ION. WASH CLOTHING BEFORE REUSE. EYE:FLUSH IMMEDIATELY WITH
LARGE AMOUNTS OF WATER FOR AT LEAST 15 MINUTES. CONSULT A
PHYSICIAN. INGESTION:GET MEDICAL ATTENTION IMMEDIATELY.

Flash Point Method:SCC
Flash Point:63.0F,17.2C
Lower Limits:2.0%
Upper Limits:12.0%
Extinguishing Media:WATER FOG, ALCOHOL, DRY CHEMICAL.
Fire Fighting Procedures:WEAR NIOSH/MSHA APPROVED SCBA & FULL
PROTECTIVE EQUIPMENT . WATER MAY BE USED TO COOL CONTAINERS. IF
WATER IS USED FOG NOZZLES ARE PREFERRED.
Unusual Fire/Explosion Hazard:KEEP CNTNRS TIGHTLY CLSD. VAPS MAY
MIGRATE TO IGNIT SOURCE & CAUSE FLASH FIRE. ISOLATE FROM HEAT,
SPKS, ELEC EQUIP, APPLIANCE, PILOT LIGHTS, FLAMES & (SUP DAT)

Spill Release Procedures:IN CASE OF SPILLAGE, ABSORB WITH INERT
MATERIAL AND DISPOSE OF IN ACCORDANCE WITH APPLICABLE REGULATIONS
OF E.P.A. AND OTHER LOCAL, STATE AND FEDERAL AUTHORITIES.
Neutralizing Agent:NONE SPECIFIED BY MANUFACTURER.

Handling and Storage Precautions:STORE AWAY FROM HEAT, SPARKS AND OPEN
FLAME. AVOID PROLONGED SKIN CONTACT. DO NOT BREATHE SPRAY MIST.
AVOID CONTACT WITH EYES, SKIN AND CLOTHING.
Other Precautions:STORE IN COOL, DRY AREA WITH VENT SUITABLE FOR
STORING MATLS SHOWN IN INGS. GROUND CNTNRS WHILE POURING. AVOID
SPONTANEOUS COMBUST OF CONTAM RAGS/OTHER ORG MATLS. EMPTY CNTNRS
MAY RETAIN HAZ PROPERTIE S & CAN BE DANGEROUS.

Respiratory Protection:NIOSH/MSHA APPRVD RESP TYPES SUITABLE FOR MATLS
IN INGS REC. APPRVD CHEM/MECH FILTERS REC WHEN VENT IS RESTRICTED.
DO NOT BRTHE (DUST, VAPS/SPRAY MIST). WEAR APPROP RESP (NIOSH/MSHA
APPRVD) DURING & A FTER APPLICATN UNLESS AIR (SUPP DATA)
Ventilation:SUFFICIENT VENT, IN VOL & PATTERN, SHOULD BE PROVIDED TO
KEEP AIR CONTAM BELOW CURRENT APPLIC OSHA PEL/ACGIH'S (SUPDAT)
Protective Gloves:CHEMICAL RESISTANT PLASTIC OR RUBBER.
Eye Protection:ANSI APPROVED CHEM WORKERS GOGGS(SUPDAT)
Other Protective Equipment:ANSI APPRVD EMER EYEWASH & DELUGE SHOWER AS
REQ TO AVOID WETTING CLTHG. USE PROT CREAMS WHERE SKIN CONT
(SUPDAT)
Work Hygienic Practices:WASH THOROUGHLY AFTER HANDLING. REMOVE AND WASH
CONTAMINATED CLOTHING BEFORE REUSE.
Supplemental Safety and Health
EXPLO HAZS:OTHER SOURCES OF IGNIT. FLAM LIQ & VAP. RESP PROT:MONITORING
RECORDS VAP/MIST LEVELS BELOW APPLIC LIMS. FOLLOW RESP MFR
DIRECTIONS FOR USE. VENT:TLV LIM. USE W/ADEQ VENT. EYE PROT:AND
FULL LENGTH FACE SHIELD . OTHER PROT EQUIP:IS LIKELY.

Boiling Pt:B.P. Text:>180F,>82C
Vapor Pres:SEE INGS
Vapor Density:HVR/AIR
Spec Gravity:0.9
Evaporation Rate & Reference:SLOWER THAN ETHER
Solubility in Water:INSOLUBLE
Appearance and Odor:LIQUID WITH AN ALCOHOL ODOR.
Percent Volatiles by Volume:100

Stability Indicator/Materials to Avoid:YES
STRONG OXIDIZING AGENTS SUCH AS ALUMINUM, ZINC, TIN, ETC. AVOID
CYANIDES, SULFIDES, SULFITES & STRONG BASES.
Stability Condition to Avoid:EXCESSIVE HEAT, SPARKS OR OPEN FLAME.
Hazardous Decomposition Products:NONE SPECIFIED BY MANUFACTURER.

Waste Disposal Methods:PLACE IN CLOSED CONTAINERS. DISPOSE OF PRODUCT
IN ACCORDANCE WITH LOCAL, COUNTY, STATE AND FEDERAL REGULATIONS.

Disclaimer (provided with this information by the compiling agencies):
This information is formulated for use by elements of the Department
of Defense. The United States of America in no manner whatsoever,
expressly or implied, warrants this information to be accurate and
disclaims all liability for its use. Any person utilizing this
document should seek competent professional advice to verify and
assume responsibility for the suitability of this information to their
particular situation.